U3-02A Mix PumpManual No. 513606 Rev. 0, April, 2004Owner's/Service Manual

4B. Mix Pump Hose Installation.Follow the steps below to install the mix pump hose.1. Turn pump on.2. Feed one end of mix pump hose into the entering

53-WAYTEE CONNECTION10. Connect free end of mix pump hose to 3-way Tee as shown in Figure D. When all connections are complete the 3-way Tee

6

73.1 SAFETY PRECAUTIONSDo not attempt to operate the U3-02A pump until the safetyprecautions and operating instructions in the manual areread complet

8Figure 5Mix Pump OperationROLLERCOVER/CLAMP3-WAY TEEINLET SIDEFigure 6Removing PartsMIX PILLOWD. Overpressure Relief: Excess pressure is relievedback

9CAUTIONSystem Under PressureNever disconnect hoses from freezer or pump withoutfirst opening spigot to relieve pressure.NOTEIf the mix lines or air l

103.7 CLEANING MIX LINESThe mix lines must be cleaned and sanitized wheneverchanging mix or whenever the freezer is off for an extendedperiod of time

114.1 OVERRUN ADJUSTMENTThe product when served is a combination of air and mix.Overrun is a measure of the amount of air blended into themix.Overrun

12RollerCover/ClampInletSideDischargeSideCover/ClampDischargeInletRoller6. Reconnect mix pump hose to adapter.7. Turn pump on.8. Gently pull on the di

13SECTION 5TROUBLESHOOTING1. PUMP MOTOR DOES NOT RUNPower to pump is off. Supply power to pump.Low voltage. Check for low voltage.Mix pump hose jammed

14PMUPHGUORHTDEEFT'NOWESOHPMUPXIMTNEMECALPER.5.revocpmupximfoelohegrahcsidotniesohgnideeF .revocfoedispu-kcipotniesohdeeF.ylerauqstuctonsdneesoH

15SECTION 6REPLACEMENT PARTS INFORMATIONFigure 10Pump and Decal Assembly6.1 HOW TO ORDER REPLACEMENT PARTSTo assure the receipt of the proper replace

16

17OPTIONAL MOUNTING KITSEE SERVICE REFERENCE, PAGE 19

18

19

20

21

22

23WARRANTYMIX TRANSFER PUMPS / COCKTAIL / SLUSH1. Scope: Stoelting LLC warrants to the first user (the “Buyer”) that the evaporator assembly and

This manual provides basic information about the mix pump and its components. Instructions and suggestions aregiven covering its basic operation and

24

Safety Alert Symbol:This symbol Indicates danger, warning or caution.Attention is required in order to avoid serious personalinjury. The message that

TABLE OF CONTENTSSECTION 1 — INTRODUCTION ...

LIST OF ILLUSTRATIONSFigure Description Page1 U3-02A Pump ...

11.1 DESCRIPTIONThe Model U3-02A Remote Mix Pump is specially de-signed for use with Stoelting remote pressurized freezers.Used with large capacity m

2

32.1 SHIPMENT AND TRANSITThe mix pump has been completely assembled, operatedand inspected at the factory. Upon arrival at the finaldestination, the